Login Register

Thread Rating:
  • 1 Vote(s) - 4 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Greetings..and..Transmission
#45
(05-29-2015, 09:49 PM)fixkick Wrote: that bearing is bad. no bearings are allowed to make noise unless dry.

next is measure and document the magic gap. with feeler gauges.


if it shifted ok, then the synchro's are ok
but check the sychro gap next.

Thanks for the checkpoints and suggestions.

I can spin that bearing fast as I can, and though it is not totally filled with oil I guess due to draining, it makes a racket that it clearly should not. The output shaft bearing is quiet. So, if the needle bearing is still good for 5th, I would hope that might explain my banshee wail when that area was loaded more.

My gap is tight there at main bearing land, a .005 won't even go in between either side of it. So either I'm poking it in the wrong location, or I'll have to pick up a more precise feeler set.

The rebuild kit came with the 5 syncros, so I was planning to replace all of them. Only shifting problems I ever had was that first was occasionally hard to get into when stopped, you'd have to go into reverse a little, or ease it in (might have been clutch not disengaging fully). Sometimes reverse grinded going in, but possible I was too fast on the action.

The sycros look rather better than I expected for all the noise I've heard from them over the years and blowing a shift here and there. But the thing shifts every time reliably in general, no popping out of gear. Last time I took it for inspection though, first shifted different after (a little harder), like they forced it into first instead of doing my trick. Undecided

Setting up my official take-apart table now. Smile
Reply


Messages In This Thread
Greetings..and..Transmission - by GeoHacker - 11-27-2014, 05:31 PM
RE: Greetings..and..Transmission - by fixkick - 11-27-2014, 11:37 PM
RE: Greetings..and..Transmission - by GeoHacker - 11-28-2014, 09:24 PM
RE: Greetings..and..Transmission - by GeoHacker - 11-29-2014, 02:21 PM
RE: Greetings..and..Transmission - by fixkick - 11-29-2014, 09:30 PM
RE: Greetings..and..Transmission - by GeoHacker - 12-05-2014, 07:11 AM
RE: Greetings..and..Transmission - by fixkick - 12-05-2014, 08:01 AM
RE: Greetings..and..Transmission - by GeoHacker - 01-02-2015, 08:36 AM
RE: Greetings..and..Transmission - by fixkick - 01-02-2015, 10:36 PM
RE: Greetings..and..Transmission - by GeoHacker - 02-01-2015, 06:19 AM
RE: Greetings..and..Transmission - by fixkick - 02-01-2015, 06:36 AM
RE: Greetings..and..Transmission - by GeoHacker - 02-10-2015, 01:44 AM
RE: Greetings..and..Transmission - by fixkick - 02-10-2015, 05:17 AM
RE: Greetings..and..Transmission - by GeoHacker - 03-01-2015, 07:50 AM
RE: Greetings..and..Transmission - by fixkick - 03-01-2015, 10:56 AM
RE: Greetings..and..Transmission - by GeoHacker - 03-09-2015, 10:20 AM
RE: Greetings..and..Transmission - by hatchetman - 03-09-2015, 11:15 AM
RE: Greetings..and..Transmission - by GeoHacker - 04-06-2015, 09:44 AM
RE: Greetings..and..Transmission - by fixkick - 04-06-2015, 09:36 PM
RE: Greetings..and..Transmission - by GeoHacker - 04-09-2015, 05:00 AM
RE: Greetings..and..Transmission - by fixkick - 04-09-2015, 06:13 AM
RE: Greetings..and..Transmission - by GeoHacker - 04-25-2015, 12:45 PM
RE: Greetings..and..Transmission - by fixkick - 04-25-2015, 11:56 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-09-2015, 11:31 AM
RE: Greetings..and..Transmission - by fixkick - 05-09-2015, 10:30 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-10-2015, 06:04 AM
RE: Greetings..and..Transmission - by fixkick - 05-10-2015, 06:09 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-23-2015, 12:12 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-23-2015, 07:02 PM
RE: Greetings..and..Transmission - by fixkick - 05-24-2015, 12:46 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-24-2015, 09:56 AM
RE: Greetings..and..Transmission - by fixkick - 05-24-2015, 10:04 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-26-2015, 05:04 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-26-2015, 07:58 AM
RE: Greetings..and..Transmission - by fixkick - 05-26-2015, 07:56 AM
RE: Greetings..and..Transmission - by fixkick - 05-26-2015, 08:18 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-26-2015, 09:30 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-28-2015, 02:34 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-28-2015, 05:58 PM
RE: Greetings..and..Transmission - by fixkick - 05-28-2015, 09:59 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-29-2015, 07:34 AM
RE: Greetings..and..Transmission - by fixkick - 05-29-2015, 11:02 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-29-2015, 03:05 PM
RE: Greetings..and..Transmission - by fixkick - 05-29-2015, 09:49 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-30-2015, 12:48 PM
RE: Greetings..and..Transmission - by fixkick - 05-31-2015, 12:18 AM
RE: Greetings..and..Transmission - by GeoHacker - 05-31-2015, 12:46 PM
RE: Greetings..and..Transmission - by fixkick - 05-31-2015, 01:31 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-31-2015, 02:16 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-31-2015, 04:45 PM
RE: Greetings..and..Transmission - by GeoHacker - 05-31-2015, 08:23 PM
RE: Greetings..and..Transmission - by fixkick - 06-01-2015, 12:21 AM
RE: Greetings..and..Transmission - by fixkick - 06-02-2015, 01:59 AM
RE: Greetings..and..Transmission - by GeoHacker - 06-02-2015, 08:33 AM
RE: Greetings..and..Transmission - by GeoHacker - 06-02-2015, 03:32 PM
RE: Greetings..and..Transmission - by fixkick - 06-02-2015, 09:19 PM
RE: Greetings..and..Transmission - by GeoHacker - 06-03-2015, 07:54 AM
RE: Greetings..and..Transmission - by fixkick - 06-03-2015, 09:35 AM
RE: Greetings..and..Transmission - by GeoHacker - 06-04-2015, 10:41 AM
RE: Greetings..and..Transmission - by fixkick - 06-04-2015, 11:01 PM
RE: Greetings..and..Transmission - by GeoHacker - 06-06-2015, 11:35 AM
RE: Greetings..and..Transmission - by fixkick - 06-06-2015, 10:36 PM
RE: Greetings..and..Transmission - by GeoHacker - 06-08-2015, 07:54 AM
RE: Greetings..and..Transmission - by GeoHacker - 06-08-2015, 01:08 PM
RE: Greetings..and..Transmission - by GeoHacker - 07-31-2015, 05:17 AM
RE: Greetings..and..Transmission - by fixkick - 07-31-2015, 05:40 AM
RE: Greetings..and..Transmission - by GeoHacker - 07-31-2015, 03:26 PM
RE: Greetings..and..Transmission - by fixkick - 08-03-2015, 06:09 AM
RE: Greetings..and..Transmission - by GeoHacker - 08-17-2015, 07:02 AM
RE: Greetings..and..Transmission - by fixkick - 08-17-2015, 09:39 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-02-2015, 12:36 PM
RE: Greetings..and..Transmission - by fixkick - 09-02-2015, 10:40 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-05-2015, 03:05 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-05-2015, 07:57 PM
RE: Greetings..and..Transmission - by fixkick - 09-06-2015, 12:00 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-09-2015, 12:01 PM
RE: Greetings..and..Transmission - by fixkick - 09-10-2015, 12:18 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-10-2015, 10:09 PM
RE: Greetings..and..Transmission - by fixkick - 09-10-2015, 10:36 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-12-2015, 09:06 AM
RE: Greetings..and..Transmission - by fixkick - 09-12-2015, 10:46 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-19-2015, 03:54 AM
RE: Greetings..and..Transmission - by fixkick - 09-19-2015, 05:07 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-23-2015, 03:47 AM
RE: Greetings..and..Transmission - by fixkick - 09-23-2015, 06:24 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-23-2015, 06:53 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-23-2015, 12:21 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-25-2015, 08:02 AM
RE: Greetings..and..Transmission - by fixkick - 09-25-2015, 09:06 AM
RE: Greetings..and..Transmission - by GeoHacker - 09-25-2015, 11:08 PM
RE: Greetings..and..Transmission - by GeoHacker - 09-30-2015, 07:14 AM
RE: Greetings..and..Transmission - by fixkick - 09-30-2015, 01:10 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-01-2015, 05:55 AM
RE: Greetings..and..Transmission - by fixkick - 10-01-2015, 07:58 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-01-2015, 01:21 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-02-2015, 12:52 PM
RE: Greetings..and..Transmission - by fixkick - 10-02-2015, 09:42 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-03-2015, 03:21 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-05-2015, 01:17 PM
RE: Greetings..and..Transmission - by fixkick - 10-06-2015, 07:37 AM
RE: Greetings..and..Transmission - by zukitrek - 10-07-2015, 01:32 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-07-2015, 11:27 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-07-2015, 03:54 PM
RE: Greetings..and..Transmission - by zukitrek - 10-08-2015, 01:54 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-08-2015, 11:32 AM
RE: Greetings..and..Transmission - by zukitrek - 10-09-2015, 12:22 AM
RE: Greetings..and..Transmission - by fixkick - 10-09-2015, 01:33 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-09-2015, 08:29 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-12-2015, 09:54 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-12-2015, 03:45 PM
RE: Greetings..and..Transmission - by fixkick - 10-13-2015, 01:24 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-13-2015, 12:57 PM
RE: Greetings..and..Transmission - by fixkick - 10-14-2015, 12:39 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-14-2015, 07:39 AM
RE: Greetings..and..Transmission - by fixkick - 10-14-2015, 08:57 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-15-2015, 11:19 AM
RE: Greetings..and..Transmission - by fixkick - 10-15-2015, 10:05 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-16-2015, 07:14 AM
RE: Greetings..and..Transmission - by fixkick - 10-16-2015, 08:11 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-16-2015, 01:53 PM
RE: Greetings..and..Transmission - by fixkick - 10-16-2015, 09:18 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-18-2015, 11:19 AM
RE: Greetings..and..Transmission - by fixkick - 10-18-2015, 09:07 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-19-2015, 11:17 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-21-2015, 05:27 PM
RE: Greetings..and..Transmission - by zukitrek - 10-22-2015, 01:43 AM
RE: Greetings..and..Transmission - by fixkick - 10-22-2015, 03:08 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-22-2015, 07:47 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-24-2015, 07:41 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-24-2015, 01:49 PM
RE: Greetings..and..Transmission - by zukitrek - 10-22-2015, 03:19 AM
RE: Greetings..and..Transmission - by fixkick - 10-25-2015, 03:50 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-25-2015, 11:37 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-25-2015, 02:29 PM
RE: Greetings..and..Transmission - by fixkick - 10-25-2015, 10:04 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-26-2015, 05:36 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-26-2015, 10:58 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-30-2015, 01:08 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-30-2015, 05:42 PM
RE: Greetings..and..Transmission - by fixkick - 10-30-2015, 09:47 PM
RE: Greetings..and..Transmission - by GeoHacker - 10-31-2015, 08:16 AM
RE: Greetings..and..Transmission - by GeoHacker - 10-31-2015, 10:02 AM
RE: Greetings..and..Transmission - by GeoHacker - 11-04-2015, 05:50 AM
RE: Greetings..and..Transmission - by fixkick - 11-04-2015, 06:27 AM
RE: Greetings..and..Transmission - by GeoHacker - 11-24-2015, 01:10 AM
RE: Greetings..and..Transmission - by fixkick - 11-24-2015, 01:28 AM
RE: Greetings..and..Transmission - by GeoHacker - 11-24-2015, 06:47 AM
RE: Greetings..and..Transmission - by fixkick - 11-24-2015, 06:57 AM
RE: Greetings..and..Transmission - by GeoHacker - 12-06-2015, 05:32 AM
RE: Greetings..and..Transmission - by fixkick - 12-06-2015, 09:50 PM

Forum Jump:


Users browsing this thread: 14 Guest(s)