12-13-2018, 04:13 AM
Hey everyone, I'm after a bit of help with my Suzuki escudo. Symptoms are:
I'm only getting 320km from a full tank of gas.
Slight bog on acceleration (hot and cold), but only when first pressing accelerator pedal. Revs and accelerates great right up to 100kph otherwise.
Low rpm at idle, engine shakes a little and seems to misfire at idle.
I have tested and calibrated the tps according to fix kick instructions. Everything checks out right apart from the idle switch goes from 0v at idle to 11.7v off idle. Shouldn't it be 5v? Is this a clue to some of the symptoms I'm experiencing?
I've given it a good tune up. New HV leads, timing belt, spark plugs, dizzy cap, checked and repaired sheared crankshaft keyway, set ignition timing, checked compression (155 all cylinders), checked fuel pressure (36psi).
Any advice would be awesome thanks!
Brendon
I'm only getting 320km from a full tank of gas.
Slight bog on acceleration (hot and cold), but only when first pressing accelerator pedal. Revs and accelerates great right up to 100kph otherwise.
Low rpm at idle, engine shakes a little and seems to misfire at idle.
I have tested and calibrated the tps according to fix kick instructions. Everything checks out right apart from the idle switch goes from 0v at idle to 11.7v off idle. Shouldn't it be 5v? Is this a clue to some of the symptoms I'm experiencing?
I've given it a good tune up. New HV leads, timing belt, spark plugs, dizzy cap, checked and repaired sheared crankshaft keyway, set ignition timing, checked compression (155 all cylinders), checked fuel pressure (36psi).
Any advice would be awesome thanks!
Brendon
1992 Suzuki Escudo G16A 16v LWB 4speed auto[font=Courier][size=small][/size][/font]